Bremach T-Rex

Differential fluid capacity & service interval

Bremach T-Rex differential fluid capacity is 2 liters. Service intervals include 30000 km/1200 hours and 40000 km/800 hours. The data covers 8 configurations.

The configuration chart below lists fill volumes and service intervals for each engine and trim variant.

TypeSpecifications
  • T-Rex 3.0 Euro 5 + DPF, F1C (2011- )
  • Front
  • Use: Normal
  • Capacity 2 liter
  • Change 30000 km/ 1200 hours
  • Code: 4x4
  • T-Rex 3.0 Euro 5 + DPF, F1C (2011- )
  • Rear
  • Use: Normal
  • Capacity 2 liter
  • Change 30000 km/ 1200 hours
  • T-Rex 2.3 Euro 4, F1A (2010- )
  • Front
  • Use: Normal
  • Capacity 2 liter
  • Change 40000 km/ 800 hours
  • Code: 4x4
  • T-Rex 2.3 Euro 4, F1A (2010- )
  • Rear
  • Use: Normal
  • Capacity 2 liter
  • Change 40000 km/ 800 hours
  • T-Rex 3.0 (107 kW) Euro 4 + DPF, F1C (2010-2012)
  • Front
  • Use: Normal
  • Capacity 2 liter
  • Change 40000 km/ 800 hours
  • Code: 4x4
  • T-Rex 3.0 (107 kW) Euro 4 + DPF, F1C (2010-2012)
  • Rear
  • Use: Normal
  • Capacity 2 liter
  • Change 40000 km/ 800 hours
  • T-Rex 3.0 (130 kW) Euro 4 + DPF, F1C (2010-2012)
  • Front
  • Use: Normal
  • Capacity 2 liter
  • Change 40000 km/ 800 hours
  • Code: 4x4
  • T-Rex 3.0 (130 kW) Euro 4 + DPF, F1C (2010-2012)
  • Rear
  • Use: Normal
  • Capacity 2 liter
  • Change 40000 km/ 800 hours

Additional Notes

  • Across all Bremach T-Rex configurations listed, both the front and rear differentials share an identical 2-liter fluid capacity. A fill volume of this magnitude is typical for light commercial vehicle axle differentials, where the housing is sized to keep gear sets and bearings adequately lubricated under load.
  • The 2-liter capacity figure applies equally to the front and rear differentials, meaning neither axle requires a larger reservoir than the other in any of the listed configurations.
  • The 2.3 Euro 4 F1A and the 3.0 Euro 4 F1C variants share a change interval of 40,000 km or 800 hours under normal use conditions. The dual-unit interval, expressed in both distance and operating hours, accommodates vehicles that may accumulate engine hours through low-speed or stationary work rather than road mileage alone.
  • The 3.0 Euro 5 F1C variant carries a shorter distance interval of 30,000 km compared to the 40,000 km specified for the Euro 4 F1C variants. This represents a 25 percent reduction in the kilometer-based service interval between the two emission standard generations of the same F1C engine family.
  • While the Euro 5 F1C variant has a shorter distance interval, the hour-based interval is 1,200 hours, which is 50 percent longer than the 800-hour interval assigned to the Euro 4 variants. The two metrics therefore move in opposite directions between these generations.
  • The 3.0 F1C engine appears in two Euro 4 power outputs, 107 kW and 130 kW, both paired with a diesel particulate filter. Despite the difference in output, both share identical differential fluid capacities and change intervals, indicating the drivetrain specifications are not differentiated by engine tune within the Euro 4 F1C range.
  • All intervals listed apply under normal use conditions. No severe-use intervals are specified for any of the T-Rex differential configurations in the provided data.

Other Systems