Chrysler 300C, LE (EU)

Transfer case fluid capacity & service interval

Chrysler 300C, LE (EU) transfer case fluid capacity ranges from 0,6 to 1 liter. Service intervals require a change at 77000 km. The data covers 7 configurations.

The configuration chart below lists fill volumes and service intervals for each engine and trim variant.

TypeSpecifications
300C 3.5 V6 AWD (2008-2010)
  • Use: Normal
  • Capacity 1 liter
  • Code: Borg Warner 44-40
300C 5.7 HEMI V8 AWD (2008-2010)
  • Use: Normal
  • Capacity 1 liter
  • Code: Borg Warner 44-40
300C 3.5 V6 AWD (2007-2008)
  • Use: Normal
  • Capacity 0,6 liter
  • Code: MS140
300C 5.7 HEMI V8 AWD (2007-2008)
  • Use: Normal
  • Capacity 0,6 liter
  • Code: MS140
300C 5.7 HEMI V8 AWD (2007-2008)
  • Use: Severe
  • Capacity 0,6 liter
  • Change 77000 km
  • Code: MS140
300C 3.5 V6 AWD (2006-2007)
  • Use: Severe
  • Capacity 0,6 liter
  • Change 77000 km
  • Code: MS140
300C 5.7 HEMI V8 AWD (2006-2007)
  • Use: Severe
  • Capacity 0,6 liter
  • Change 77000 km
  • Code: MS140

Additional Notes

  • The Chrysler 300C LE (EU) transfer case fluid capacity changed from 0.6 liters to 1.0 liter between the 2007-2008 and 2008-2010 model year ranges, affecting both the 3.5 V6 AWD and 5.7 HEMI V8 AWD configurations.
  • The 0.6-liter figure seen across the 2006-2008 entries is a relatively small transfer case fill volume, consistent with the compact, single-speed transfer units commonly used in car-based AWD platforms of that era.
  • The 1.0-liter capacity recorded for the 2008-2010 variants represents a 67 percent increase over the earlier figure, which typically reflects a physically larger or redesigned transfer case unit requiring a greater fluid volume to maintain adequate lubrication.
  • A 77,000 km fluid change interval is specified under severe use conditions for the 3.5 V6 AWD covering 2006-2007. Severe use classifications generally apply to operating conditions such as frequent towing, off-road driving, or repeated short-trip cycles that accelerate fluid degradation.
  • The 5.7 HEMI V8 AWD for 2007-2008 carries both a normal-use and a severe-use entry, each at 0.6 liters capacity. The severe-use entry adds a 77,000 km change interval, while the normal-use entry lists no change interval.
  • No fluid change interval appears in the normal-use rows for either engine variant across any model year range. Interval data in the specifications is present only where the use condition is listed as severe.
  • Both the 3.5 V6 and 5.7 HEMI V8 AWD variants share identical transfer case fluid capacities within the same model year ranges, indicating the transfer case unit was not engine-specific during the 2006-2010 period covered by these specifications.

Other Systems