Volvo FLC (EU)

Manual transmission fluid capacity & service interval

Volvo FLC (EU) manual transmission fluid capacity is 3,2 liters. Service intervals include checks every 6 months and changes every 120000 km or 12 months. 1 configuration is covered.

The configuration chart below lists fill volumes and service intervals for each engine and trim variant.

TypeSpecifications
FLC-140 (D4A) (1996-2000)
  • Use: Normal
  • Capacity 3,2 liter
  • Check 6 months
  • Change 120000 km/ 12 months
  • Code: 5/1

Additional Notes

  • The FLC-140 (D4A) manual transmission holds 3.2 liters, a figure consistent with a service fill rather than an overhaul capacity, meaning the fluid volume applies to routine top-up and drain-and-fill procedures on an assembled unit.
  • The change interval for the Volvo FLC (EU) FLC-140 (D4A) manual transmission is set at 120,000 km or 12 months, whichever comes first, under normal use conditions.
  • A separate check interval of every 6 months is specified alongside the annual change interval, indicating that fluid level verification is expected at twice the frequency of a full fluid replacement.
  • The 12-month change interval means a calendar-based limit applies regardless of mileage accumulation, so low-mileage operation does not extend the service period beyond one year under normal use.
  • The single use condition listed for the FLC-140 (D4A) is normal, and both the 120,000 km mileage threshold and the 12-month time limit are tied directly to that operating classification.

Other Systems