Renault Express II Van, XJK (EU)

Brake fluid capacity & service interval

Renault Express II Van, XJK (EU) requires brake fluid with a capacity range of 0.5 to 1.0 liters. Service intervals occur every 120000 km or 48 months. The data covers 4 configurations.

The configuration chart below lists fill volumes and service intervals for each engine and trim variant.

TypeSpecifications
Express II Van 1.5 Blue dCi 75 DPF Euro 6d (2023- )
  • Use: Normal
  • Between min and max.
  • Change 120000 km/ 48 months
Express II Van 1.5 Blue dCi 95 DPF Euro 6d (2023- )
  • Use: Normal
  • Between min and max.
  • Change 120000 km/ 48 months
Express II Van 1.5 Blue dCi 75 DPF Euro 6d-temp (2021-2023)
  • Use: Normal
  • Between min and max.
  • Change 120000 km/ 48 months
Express II Van 1.5 Blue dCi 95 DPF Euro 6d-temp (2021-2023)
  • Use: Normal
  • Between min and max.
  • Change 120000 km/ 48 months

Additional Notes

  • All four configurations of the Renault Express II Van share a single brake fluid capacity specification: the reservoir level must be kept between the minimum and maximum marks rather than filled to a fixed volume. This range-based fill method is standard for hydraulic brake systems, where the fluid level naturally drops slightly as brake pads wear and the caliper pistons extend further.
  • The hydraulic system note applies to both the brake and clutch circuits together, reflecting a design where a single reservoir supplies fluid to both systems. This shared arrangement is common in vehicles with hydraulically actuated manual clutches.
  • The change interval is identical across all listed configurations at 120,000 km or 48 months under normal use conditions, whichever comes first. The time-based limit of 48 months exists because brake fluid is hygroscopic and absorbs moisture from the atmosphere over time, lowering its boiling point regardless of mileage accumulated.
  • The Euro 6d-temp variants covering 2021-2023 and the Euro 6d variants starting from 2023 carry the same 120,000 km / 48-month interval, meaning the transition between emission standards introduced no change to brake fluid service requirements for the 1.5 Blue dCi engine family.
  • Both power outputs available in the Express II Van lineup, the 75 hp and 95 hp versions of the 1.5 Blue dCi, share identical brake fluid specifications. The difference in output between these two variants does not affect the brake fluid capacity guidance or the service interval.

Other Systems