Tata Nexon

Manual transmission fluid capacity & service interval

Tata Nexon manual transmission fluid capacity is 2,4 liters. Service intervals include checks at 7500 km/6 months and 75000 km/60 months, with a fluid change at 75000 km/60 months. The data covers 6 configurations.

The configuration chart below lists fill volumes and service intervals for each engine and trim variant.

TypeSpecifications
Nexon 1.2 Revotron (2020- )
  • Use: Normal
  • Capacity 2,4 liter
  • Check 7500 km/ 6 months
  • Change 75000 km/ 60 months
  • Code: TA 6300 6/1
Nexon 1.5 Revotorq (2020- )
  • Use: Normal
  • Capacity 2,4 liter
  • Check 7500 km/ 6 months
  • Change 75000 km/ 60 months
  • Code: TA 6300 6/1
Nexon 1.2 Revotron (2019-2020)
  • Use: Normal
  • Capacity 2,4 liter
  • Check 7500 km/ 6 months
  • Change 75000 km/ 60 months
  • Code: TA 6300 6/1
Nexon 1.5 Revotorq (2019-2020)
  • Use: Normal
  • Capacity 2,4 liter
  • Check 7500 km/ 6 months
  • Change 75000 km/ 60 months
  • Code: TA 6300 6/1
Nexon 1.2 Revotron (2017-2019)
  • Use: Normal
  • Capacity 2,4 liter
  • Check 75000 km/ 60 months
  • Code: TA 6300 6/1
Nexon 1.5 Revotorq (2017-2019)
  • Use: Normal
  • Capacity 2,4 liter
  • Check 75000 km/ 60 months
  • Code: TA 6300 6/1

Additional Notes

  • All six Tata Nexon manual transaxle configurations share a uniform fluid capacity of 2.4 liters, covering both the 1.2 Revotron petrol and 1.5 Revotorq diesel variants across all listed model years.
  • A transaxle combines the transmission and drive axle into a single housing, which is why its fluid capacity is specified and serviced separately from engine oil.
  • The 2.4-liter figure represents a service fill capacity, meaning the volume required when refilling a drained but otherwise intact unit during routine maintenance rather than a full overhaul.
  • The 1.2 Revotron and 1.5 Revotorq variants built in 2017-2019 carry only a check interval of 75,000 km or 60 months, with no separate fluid change interval listed in the specifications.
  • From 2019 onward, both the 1.2 Revotron and 1.5 Revotorq specifications add a periodic check interval of 7,500 km or 6 months alongside the 75,000 km or 60-month change interval, a detail absent from the earlier 2017-2019 entries.
  • The 75,000 km or 60-month change interval applies under normal use conditions, meaning standard road driving without the additional stress associated with severe-duty classifications such as frequent towing or off-road operation.
  • The 7,500 km or 6-month check interval introduced in the 2019-2020 and later specifications serves as a monitoring step rather than a full fluid replacement, allowing for level verification and early detection of leaks or contamination between full change intervals.
  • The capacity figure of 2.4 liters remains consistent across the petrol and diesel variants, indicating that the Tata Nexon 1.2 Revotron and 1.5 Revotorq share a manual transaxle with the same fluid volume requirement despite differing engine outputs.

Other Systems