Suzuki Jimny, A6G

Brake fluid capacity & service interval

Suzuki Jimny A6G uses brake fluid with a capacity range between min and max. Service intervals include checks at 20000 km or 12 months and changes at 40000 km or 24 months. The data covers 2 configurations.

The configuration chart below lists fill volumes and service intervals for each engine and trim variant.

TypeSpecifications
  • Jimny 1.5 AWD, A6G415 (2018- )
  • (DOT3 cap)
  • Use: Normal
  • Between min and max.
  • Check 20000 km/ 12 months
  • Change 40000 km/ 24 months
  • Jimny 1.5 AWD, A6G415 (2018- )
  • (DOT4 cap)
  • Use: Normal
  • Between min and max.
  • Check 20000 km/ 12 months
  • Change 40000 km/ 24 months

Additional Notes

  • The Suzuki Jimny 1.5 AWD (A6G415) brake fluid reservoir carries no fixed volume target. The specified fill level is between the minimum and maximum marks on the reservoir, which is a range-based standard rather than a precise capacity figure.
  • Two brake fluid cap types are listed for the Jimny 1.5 AWD (A6G415): one marked DOT3 and one marked DOT4. The cap marking on the reservoir identifies which fluid grade the hydraulic brake system requires, and the two configurations are treated as separate specifications.
  • Regardless of whether the vehicle has a DOT3 or DOT4 cap, the check interval is the same: every 20,000 km or 12 months under normal use conditions, whichever comes first.
  • The change interval for brake fluid in both cap configurations is 40,000 km or 24 months under normal use conditions. DOT fluids are hygroscopic, meaning they absorb moisture over time, which lowers the boiling point of the fluid and is the primary reason periodic replacement is specified.
  • The check and change intervals share a consistent 2:1 ratio in both distance and time. A fluid check is due at half the distance and half the time of a full fluid change, meaning two check cycles occur before a replacement is required.

Other Systems