Jeep Cherokee, XJ (EU)

Power steering fluid capacity & service interval

Jeep Cherokee, XJ (EU) power steering fluid capacity is 1,2 liters. Service intervals occur every 12000 km or 12 months. The data covers 6 configurations.

The configuration chart below lists fill volumes and service intervals for each engine and trim variant.

TypeSpecifications
Cherokee 2.5 TD, XJ (1995-2001)
  • Use: Normal
  • Capacity 1,2 liter
  • Check 12000 km/ 12 months
Cherokee 2.5 TD AWD, XJ (1995-2001)
  • Use: Normal
  • Capacity 1,2 liter
  • Check 12000 km/ 12 months
Cherokee 2.5, XJ (1987-2000)
  • Use: Normal
  • Capacity 1,2 liter
  • Check 12000 km/ 12 months
Cherokee 2.5 AWD, XJ (1987-2000)
  • Use: Normal
  • Capacity 1,2 liter
  • Check 12000 km/ 12 months
Cherokee 4.0, XJ (1987-2000)
  • Use: Normal
  • Capacity 1,2 liter
  • Check 12000 km/ 12 months
Cherokee 4.0 AWD, XJ (1987-2000)
  • Use: Normal
  • Capacity 1,2 liter
  • Check 12000 km/ 12 months

Additional Notes

  • The Jeep Cherokee XJ (EU) power steering system holds 1.2 liters of fluid across all listed configurations, which is a typical capacity for a recirculating ball-type power steering rack or steering box setup common in vehicles of this era.
  • The 1.2-liter figure represents the total system capacity, encompassing the reservoir, pump, and steering gear lines rather than a partial service top-up volume.
  • All six configurations share an identical check interval of 12,000 km or 12 months under normal use conditions, meaning the interval is tied to whichever threshold is reached first.
  • The 2.5-liter petrol variants (two-wheel drive and AWD) cover the 1987-2000 model years, while the 2.5 TD and 2.5 TD AWD diesel variants span a shorter window from 1995-2001, reflecting the later introduction of the turbodiesel engine in the XJ lineup.
  • Despite the difference between petrol and turbodiesel powertrains, the power steering fluid capacity and check interval remain uniform at 1.2 liters and 12,000 km/12 months, indicating the steering hardware was not altered between these engine variants.
  • The AWD and two-wheel-drive versions of both the 2.5 and 4.0 engines share the same 1.2-liter capacity, which is consistent with the power steering pump and gear assembly being independent of the drivetrain configuration.
  • The 4.0-liter inline-six configurations, available in both two-wheel drive and AWD from 1987-2000, carry the same 1.2-liter system capacity as the smaller 2.5-liter engine variants, pointing to a shared steering system architecture across the XJ range.
  • A 12,000 km or 12-month check interval for power steering fluid is a condition-monitoring schedule rather than a mandatory fluid replacement interval, meaning the fluid level and condition are inspected at that point rather than automatically replaced.

Other Systems