Ford Maverick (USA)

Manual transmission fluid capacity & service interval

Ford Maverick (USA) manual transmission fluid capacity is 1,66 liters. Service intervals include checks at 5000 miles/5 months and 6000 miles/6 months. The data covers 6 configurations.

The configuration chart below lists fill volumes and service intervals for each engine and trim variant.

TypeSpecifications
Maverick 2.8 (170 ci) (1972-1973)
  • Use: Normal
  • Capacity 1,66 liter
  • Check 5000 miles/ 5 months
Maverick 3.3 (200 ci) (1972-1977)
  • Use: Normal
  • Capacity 1,66 liter
  • Check 5000 miles/ 5 months
Maverick 4.1 (250 ci) (1972-1977)
  • Use: Normal
  • Capacity 1,66 liter
  • Check 6000 miles/ 6 months
Maverick 4.9 (302 ci) (1971-1977)
  • Use: Normal
  • Capacity 1,66 liter
  • Check 5000 miles/ 5 months
Maverick 2.8 (170 ci) (1969-1971)
  • Use: Normal
  • Capacity 1,66 liter
  • Check 5000 miles/ 5 months
Maverick 3.3 (200 ci) (1969-1971)
  • Use: Normal
  • Capacity 1,66 liter
  • Check 5000 miles/ 5 months

Additional Notes

  • Across all six engine configurations of the Ford Maverick (USA), the manual transmission fluid capacity is uniformly 1.66 liters. This figure represents a service fill level, meaning the amount of fluid required during a routine top-up or fluid change with the transmission remaining in the vehicle, rather than a full overhaul capacity that would account for fluid retained in disassembled components.
  • The 1.66-liter capacity figure applies identically to the 2.8 L (170 ci), 3.3 L (200 ci), 4.1 L (250 ci), and 4.9 L (302 ci) engine variants, spanning inline-four, inline-six, and V8 configurations. The consistency across such a range of engine displacements suggests the same manual transmission unit was paired with multiple powertrains throughout the model's production run.
  • Five of the six listed configurations share a check interval of every 5,000 miles or 5 months, whichever comes first. The dual-trigger format, combining a mileage threshold with a time-based threshold, accounts for vehicles that accumulate low mileage over extended periods, where fluid degradation can still occur through moisture absorption and thermal cycling even without heavy use.
  • The 4.1 L (250 ci) engine variant, available from 1972-1977, carries a slightly longer check interval of 6,000 miles or 6 months under normal use conditions. This is the only configuration in the specifications to deviate from the 5,000-mile/5-month interval shared by all other listed engines.
  • The 2.8 L (170 ci) engine appears in two separate year groupings: 1969-1971 and 1972-1973. Both share identical capacity and interval specifications, though the split into distinct entries reflects a model year boundary that may correspond to other engineering or regulatory changes in those periods.
  • The 3.3 L (200 ci) engine similarly spans two separate entries, covering 1969-1971 and 1972-1977. The 1972-1977 grouping represents the longest continuous year range among all listed configurations, and both entries carry the same 1.66-liter capacity and 5,000-mile/5-month check interval.
  • All specifications are listed under normal use conditions. In automotive service contexts, normal use typically refers to operation under moderate temperatures, standard load, and routine driving patterns, as opposed to severe use, which would involve towing, extreme temperatures, or frequent short trips. No severe-use intervals are listed for any Maverick manual transmission configuration in these specifications.

Other Systems